had to take my 2012 tsx to the dealer
#121
MD has these wonderful grooves in the lane dividers over double yellow lines that cause a vibration if you drift over them. With the old ball joints, the front end would rattle and shake. With the new ones it merely vibrates.
Good stuff.
#126
I just checked with my dealer today to see if they have the parts yet and they do not. My car will have 40000 miles here in about a week or so and the clunk is starting to get worse, i can even feel it through my steering column and floorboard. I hope they get these new Ball Joints in soon as this is getting to be very frustrating.
#127
I would recommend that everyone with that problem notify their dealer in writing (an email to the service manager is fine - just make sure you get a response) or on a work order "customer complains of clunk in front end" as soon as possible so if the parts don't come in you'll still be on record of having the issue during warranty.
#128
I would recommend that everyone with that problem notify their dealer in writing (an email to the service manager is fine - just make sure you get a response) or on a work order "customer complains of clunk in front end" as soon as possible so if the parts don't come in you'll still be on record of having the issue during warranty.
#129
Special Edition
Just an FYI my 2012 SE had ball joint replaced after complaining several times and a few other local tsx owners coming to dealer and complaining...still awaiting new part
#130
I know mods can void warranty, if they can prove the issue is mod related, but what about a tsb such as this? I've had the issue for quite some time, but have since installed coilovers. Wondering if Acura would give me resistance about replacing the ball joing.
#134
1st page of the TSB
Applies To: 2009–12 TL – ALL
2009–12 TSX – ALL
Front Suspension Clunk in Hot Weather
SYMPTOM
A clunk is heard in the front suspension while driving
over irregular surfaces and in hot weather. The noise
goes away temporarily when the vehicle is lifted in the
air (the suspension is allowed to hang) and then
returned to the ground.
PROBABLE CAUSE
The lower ball joint in the knuckle can make noise
during hot weather conditions.
CORRECTIVE ACTION
Replace both of the front lower ball joints with the
service parts made to address this specific symptom. If
prior replacement, then replace both front knuckle
assemblies; press out the new lower ball joints from the
new knuckles, and press in ones listed in this bulletin.
Applies To: 2009–12 TL – ALL
2009–12 TSX – ALL
Front Suspension Clunk in Hot Weather
SYMPTOM
A clunk is heard in the front suspension while driving
over irregular surfaces and in hot weather. The noise
goes away temporarily when the vehicle is lifted in the
air (the suspension is allowed to hang) and then
returned to the ground.
PROBABLE CAUSE
The lower ball joint in the knuckle can make noise
during hot weather conditions.
CORRECTIVE ACTION
Replace both of the front lower ball joints with the
service parts made to address this specific symptom. If
prior replacement, then replace both front knuckle
assemblies; press out the new lower ball joints from the
new knuckles, and press in ones listed in this bulletin.
The following users liked this post:
gonzo08452 (12-29-2012)
#135
Pro
Which is why I think I will wait until summer. Hopefully parts are readily available and not on back order.
#136
I know mods can void warranty, if they can prove the issue is mod related, but what about a tsb such as this? I've had the issue for quite some time, but have since installed coilovers. Wondering if Acura would give me resistance about replacing the ball joint.
Anyone know if the issue would still be covered?
Anyone know if the issue would still be covered?
#137
I know mods can void warranty, if they can prove the issue is mod related, but what about a tsb such as this? I've had the issue for quite some time, but have since installed coilovers. Wondering if Acura would give me resistance about replacing the ball joint.
Anyone know if the issue would still be covered?
Anyone know if the issue would still be covered?
It is well documented that a lowered suspension can cause additional strain on non-modified suspension parts, so the dealer could argue (and possibly prevail) that your mod caused the issue.
Your contention will be that the problem is well documented and that unmodified cars have this issue so it is immaterial if your suspension was modified.
This is where your relationship with the dealer is vital. If you get along well with them then you may get lucky - otherwise you may have issues.
You can ask on your local board for recommendations of mod-friendly dealers in your area.
#138
Drifting
Anyone have isues with the stealership saying they cant reproduce the noise? I mean they should be smart enough to at least read the dam TSB and see that it says in "Hot Weather"
... It's ranging from 50F-65F here... Does anyone know if there are VIN matches to this TSB?
![Why Me](https://acurazine.com/forums/images/smilies/whyme.gif)
#142
mugen cu2
Thread Starter
^^ i went to two dealers,first one said it was a normal characteristic of the car so i waited a couple months later went to another one then they told me that they were aware of it and that Acura was working it and that they would call me as soon as they receive the parts, i do have a copy of what they did if that wold help you maybe
The following users liked this post:
LTRinENC (03-06-2013)
#151
Pro
I thought dlrs used 'chassis ears' to isolate noises. My 09 Maxima had a noise that was barely noticeable and the advisor had me fill out a 'Noise/Vibration' sheet which was essentially a questionaire to assist the tech in isolating the source. He hooked up these 'chassis ears' and was able to isolate the lower steering joint as the primary failed part. I was pretty happy they found it in one shot.
#152
I have a 2011 TSX Wagon with 7500 miles suffering from the clunking front-end problem. The vehicle was at the dealer for two days and the ball joint replacement specified in Service Bulletin 12-041 was done. When the warm weather returns, I'll let everyone know if the remedy was successful, or if we need to return for the knuckle assembly replacement. Thanks for everyone's comments!
#153
#157
just got a 2012 tsx wagon with 3000 miles on it and been only 3 weeks driving it and heard the noise. to make it worse i started to feel it under braking and acceleration from dead stop.
thanks for the tsb guys i will talk to my dealership and see what happens. currently my dealership only gave me one key and told me to come back in a week for the other. so far i went back and didnt have it ready. so now i have to go back in 3 days and ill be sure to mention this as well.
thanks for the tsb guys i will talk to my dealership and see what happens. currently my dealership only gave me one key and told me to come back in a week for the other. so far i went back and didnt have it ready. so now i have to go back in 3 days and ill be sure to mention this as well.
#158
![Thumbs Up](https://acurazine.com/forums/images/smilies/thumbsup.gif)
![Thumbs Up](https://acurazine.com/forums/images/smilies/thumbsup.gif)
Thread
Thread Starter
Forum
Replies
Last Post
IndycarFaster
2G TSX Audio, Bluetooth, Electronics & Navigation
0
09-11-2015 02:52 PM